Numerical simulation on dynamic response of reinforced concrete beams to secondary explosion
-
摘要: 为了探究钢筋混凝土梁在二次爆炸作用下的毁伤效应，开展了相关数值分析研究：利用LS-DYNA中的流固耦合算法和完全重启动技术，对钢筋混凝土梁二次爆炸试验进行了数值模拟，分析结果与试验结果基本一致，验证了模拟方法和材料模型参数的正确性；在此基础上，对二次爆炸场景进行扩展，对典型足尺钢筋混凝土梁进行建模分析，探究了爆炸场景、混凝土强度、纵筋配筋率和箍筋配筋率对二次爆炸作用下钢筋混凝土梁损伤破坏模式和动力响应的影响。结果表明：由于压力膜效应的存在，在保持爆炸总当量不变的前提下，单次爆炸对钢筋混凝土梁构件造成的损伤比连续两次爆炸造成的累积损伤更严重；提高混凝土强度可以显著提高二次爆炸作用下钢筋混凝土梁的抗爆性能；提高纵筋配筋率对梁抗爆性能的提升效果不明显；而对混凝土梁支座部位采用箍筋加密措施可以降低钢筋混凝土梁在爆炸作用下的剪切破坏程度，提高钢筋混凝土梁在二次爆炸作用下的抗爆性能。进一步计算得到了所涉及二次爆炸场景下两种不同设计参数钢筋混凝土梁的等损伤曲线，建立了相应的损伤程度分区图。Abstract: Terrorist attacks and local wars occur frequently, which makes the risk of buildings subjected to multiple explosions increasing. Most of the existing research focuses on the single explosion scenario, and there are few studies on the damage effect of reinforced concrete structures under multiple explosions. In order to study the damage effect of reinforcement concrete beams under secondary explosion and offset the shortcomings of the existing research, relevant numerical analysis was carried out. The damage parameters of the K&C concrete constitutive model were modified firstly. And the arbitrary Lagrangian-Eulerian method for fluid-structure interaction was used to simulate the secondary explosion experiment of reinforced concrete beam with the full restart function of LS-DYNA. The numerical analysis results were well consistent with the test results, verifying the effectiveness of the simulation method and the modified constitutive model. On this basis, the secondary explosion simulation conditions were expanded. The effects of various parameters, including scaled distance, concrete compressive strength, longitudinal reinforcement ratio and transverse reinforcement details, on the damage effect of typical size reinforcement concrete beams under secondary explosion were further analyzed. The results show that due to the compressive membrane action of reinforcement concrete beam, keeping the total equivalent TNT weight of the explosion unchanged, the damage of RC component caused by one single explosion is more serious than the cumulative damage caused by two successive explosions. The concrete compressive strength has a more significant effect on the blast resistance performance of RC beams under secondary explosion, the higher the concrete strength, the lower the damage degree of the beam under the secondary explosion. Increasing the longitudinal reinforcement ratio has no obvious effect on improving the blast resistance performance of the beam and reducing the transverse reinforcement spacing can effectively decrease the shear failure degree of reinforcement concrete beam which makes the blast resistance performance of RC beams under secondary explosion and near explosion improved. The iso-damage curves of reinforcement concrete beams with two different design parameters are further calculated and the corresponding damage degree zoning maps are established.
-
Key words:
- reinforced concrete /
- blast load /
- secondary explosion /
- fluid-structure interaction /
- dynamic response
-
图 1 K&C默认损伤曲线与修正后损伤曲线对比
Figure 1. Comparison of damage function between the K&C model default and modified parameters
图 6 试验和有限元计算的得到梁跨中挠度时程曲线对比
Figure 6. Comparisons of deflection time history at mid-span between experiment and numerical simulation
图 13 爆炸荷载作用下典型钢筋混凝土构件压力膜效应
Figure 13. Compression membrane action in a typical reinforced concrete member under blast loading
图 14 总当量相同时单次爆炸作用和二次爆炸作用损伤云图对比
Figure 14. The damage contours of single explosion and secondary explosion under the same total TNT equivalent
图 15 梁跨中位移时程曲线：Beam4~Beam7
Figure 15. Deflection time history at mid-span: Beam4−Beam7
图 17 RC梁Beam4～Beam7在二次爆炸作用下的损伤云图
Figure 17. The damage contours of Beam4−Beam7 under secondary explosion
图 18 比例距离为0.141 m/kg1/3时RC梁Beam8～Beam11损伤云图
Figure 18. Damage contours of Beam8−Bema11 with the scaled distance of 0.141 m/kg1/3
图 19 梁跨中位移时程曲线：Beam8~Beam11
Figure 19. Deflection time history at mid-span: Beam8−Beam11
图 21 梁跨中位移时程曲线：Beam4、Beam12、Beam13
Figure 21. Deflection time history at mid-span: Beam4, Beam12 and Beam13
图 22 梁跨中位移时程曲线：Beam4、Beam14～Beam16
Figure 22. Deflection time history at mid-span: Beam4, Beam14−16
图 24 Beam4，Beam14~Beam16支座反力时程曲线
Figure 24. Reaction force time history of Beam4, Beam14−Beam16 under secondary explosion
图 25 梁跨中位移时程曲线：Beam8、Beam17、Beam18
Figure 25. Deflection time history at mid-span: Beam8, Beam17 and Beam18
图 26 比例距离为0.141m/kg1/3时RC梁Beam8、Beam17、Beam18损伤云图
Figure 26. The damage contours of Beam8, Bema17 and Beam18 with scaled distance 0.141m/kg1/
图 27 不同损伤程度阈值下钢筋混凝土梁二次爆炸等损伤曲线
Figure 27. The iso-damage curves of RC beams under secondary explosion with different damage levels
图 28 二次爆炸作用下钢筋混凝土梁损伤程度分区图
Figure 28. Zoning map of the damage degree of the RC beams under secondary explosion
表 1 参数(η, λ)具体取值
Table 1. Damage parameters (η, λ) of K&C model
上升段 下降段 λ η λ η 0 0 1.70×10−4 0.73617 8.00×10−6 0.37026 3.00×10−4 0.54456 2.40×10−5 0.81341 5.50×10−4 0.37119 4.00×10−5 0.97668 1.00×10−3 0.24346 5.60×10−5 1.00000 1.65×10−3 0.16694 2.50×10−3 0.12059 3.50×10−3 0.09209 1.00×10−2 0.03876 
下载: 导出CSV
表 2 MAT_HIGH_EXPLOSIVE_BURN材料模型及EOS_JWL状态方程输入参数
Table 2. Input parameters for MAT_HIGH_EXPLOSIVE_BURN and EOS_JWL
密度/(kg·m−3) 爆速/(m·s-1) 爆压/Pa A/Pa B/Pa R1 R2 ω E0/Pa 初始相对体积 1630 6930 2.1×1010 3.712×1011 3.23×109 4.15 0.95 0.32 7×109 1
下载: 导出CSV
表 3 MAT_NULL材料模型及EOS_LINEAR_POLYNOMIAL状态方程输入参数
Table 3. Input parameters for MAT_NULL and EOS_LINEAR_POLYNOMIAL
密度/(kg·m−3) 粘滞系数/(Pa·s) C0, C1, C2, C3, C6 C4, C5 E0/Pa 初始相对体积 1.29 2×10−5 0 0.4 2.5×105 1
下载: 导出CSV
表 4 足尺钢筋混凝土梁设计参数及爆炸工况
Table 4. The details of the full-size RC beams and the explosive scenarios
编号 (装药量/kg, 爆距/m) 混凝土强度等级 纵筋 箍筋 第1次 第2次 Beam1 (45, 2) (45, 2) C30 3 14
8@200mm
Beam2 (90, 2) (45, 2) C30 3 Beam3 (135, 2) (45, 2) C30 3 Beam4 (45, 1) (45, 1) C30 3 Beam5 (45, 1) (45, 1) C40 3 Beam6 (45, 1) (45, 1) C50 3 Beam7 (45, 1) (45, 1) C60 3 Beam8 (45, 0.5) − C30 3 Beam9 (45, 0.5) − C40 3 Beam10 (45, 0.5) − C50 3 Beam11 (45, 0.5) − C60 3 Beam12 (45, 1) (45, 1) C30 3 Beam13 (45, 1) (45, 1) C30 3 Beam14 (45, 1) (45, 1) C30 3 梁端箍筋加密 Beam15 (45, 1) (45, 1) C30 3 梁端箍筋加密 Beam16 (45, 1) (45, 1) C30 3 Beam17 (45, 0.5) − C30 3 梁端箍筋加密 Beam18 (45, 0.5) − C30 3 梁端箍筋加密
下载: 导出CSV
表 5 RC梁损伤的计算结果
Table 5. Numerical results of RC-beams damage
编号 爆次 Xm/mm θmax/(°) 损伤程度 编号 爆次 Xm/mm θmax/(°) 损伤程度 Beam1 二次 7.562 0.271 轻度损伤 Beam10 单次 182.493 6.507 完全破坏 Beam2 二次 8.214 0.294 轻度损伤 Beam11 单次 143.675 5.131 完全破坏 Beam3 二次 15.188 0.544 轻度损伤 Beam12 二次 44.363 1.588 中度损伤 Beam4 二次 43.522 1.558 中度损伤 Beam13 二次 38.934 1.394 中度损伤 Beam5 二次 35.765 1.281 中度损伤 Beam14 二次 42.670 1.528 中度损伤 Beam6 二次 32.488 1.163 中度损伤 Beam15 二次 37.709 1.350 中度损伤 Beam7 二次 27.713 0.992 轻度损伤 Beam16 二次 35.057 1.255 中度损伤 Beam8 单次 254.972 9.054 完全破坏 Beam17 单次 235.966 8.389 完全破坏 Beam9 单次 215.498 7.671 完全破坏 Beam18 单次 201.104 7.164 完全破坏
下载: 导出CSV
表 6 两种方法得到二次爆炸作用下梁的跨中最大位移和支座最大转角计算结果
Table 6. Numerical results of maximum midspan displacement and maximum bearing rotation angle by ALE and CONWEP
梁编号 跨中最大位移/mm 支座最大转角/(°) 梁编号 跨中最大位移/mm 支座最大转角/(°) ALE CONWEP ALE CONWEP ALE CONWEP ALE CONWEP Beam4 43.522 46.933 1.558 1.680 Beam7 27.713 29.761 0.992 1.066 Beam5 35.765 38.608 1.281 1.382 Beam14 42.670 43.524 1.528 1.558 Beam6 32.488 33.628 1.163 1.204 Beam15 37.709 40.237 1.350 1.441
下载: 导出CSV
表 7 不同损伤阈值下等损伤曲线计算参数
Table 7. Calculation parameters of iso-damage curves under different damage levels
BeamA BeamB θmax/
(°)a1/
(m·kg−1)a2/
(m·kg−2)b/m θmax/
(°)a1/
(m·kg−1)a2/
(m·kg−2)b/m 1 0.01766 −8.81×10−6 1.4724 1 0.01194 −5.28×10−6 1.1229 2 0.01105 −4.77×10−6 0.8542 2 0.00898 −4.05×10−6 0.5772 4 0.00926 −4.26×10−6 0.4573 4 0.00808 −4.47×10−6 0.4493
下载: 导出CSV
-
[1] ABEDINI M, MUTALIB A A. Investigation into damage criterion and failure modes of RC structures when subjected to extreme dynamic loads [J]. Archives of Computational Methods in Engineering, 2020, 27(2): 501–515. DOI: 10.1007/s11831-019-09317-z. [2] SIELICKI P W, ŚLOSARCZYK A, SZULC D. Concrete slab fragmentation after bullet impact: an experimental study [J]. International Journal of Protective Structures, 2019, 10(3): 380–389. DOI: 10.1177/2041419619854764. [3] MAZURKIEWICZ L, MAŁACHOWSKI J, BARANOWSKI P. Optimization of protective panel for critical supporting elements [J]. Composite Structures, 2015, 134: 493–505. DOI: 10.1016/j.compstruct.2015.08.069. [4] WOODSON S C, KIGER S A. Stirrup requirements for blast-resistant slabs [J]. Journal of Structural Engineering, 1988, 114(9): 2057–2069. DOI: 10.1061/(ASCE)0733-9445(1988)114:9(2057). [5] KYEI C, BRAIMAH A. Effects of transverse reinforcement spacing on the response of reinforced concrete columns subjected to blast loading [J]. Engineering Structures, 2017, 142: 148–164. DOI: 10.1016/j.engstruct.2017.03.044. [6] 汪维. 钢筋混凝土构件在爆炸载荷作用下的毁伤效应及评估方法研究 [D]. 长沙: 国防科技大学, 2012: 37–57.WANG W. Study on damage effects and assessments method of reinforced concrete structural members under blast loading [D]. Changsha: Graduate School of National University of Defense Technology, 2012: 37–57. [7] 师燕超, 李忠献. 爆炸荷载作用下钢筋混凝土柱的动力响应与破坏模式 [J]. 建筑结构学报, 2008, 29(4): 112–117. DOI: 10.3321/j.issn:1000-6869.2008.04.015.SHI Y C, LI Z X. Dynamic responses and failure modes of RC columns under blast loading [J]. Journal of Building Structures, 2008, 29(4): 112–117. DOI: 10.3321/j.issn:1000-6869.2008.04.015. [8] 高超, 宗周红, 伍俊. 爆炸荷载下钢筋混凝土框架结构倒塌破坏试验研究 [J]. 土木工程学报, 2013, 46(7): 9–20. DOI: 10.15951/j.tmgcxb.2013.07.012.GAO C, ZONG Z H, WU J. Experimental study on progressive collapse failure of RC frame structures under blast loading [J]. China Civil Engineering Journal, 2013, 46(7): 9–20. DOI: 10.15951/j.tmgcxb.2013.07.012. [9] 邓国强, 杨秀敏. 钻地弹重复打击效应现场试验研究 [J]. 防护工程, 2012, 34(5): 1–5.DENG G Q, YANG X M. Experimental investigation into damage effects of repeated attacks of precision-guided penetration weapons [J]. Protective Engineering, 2012, 34(5): 1–5. [10] 李恩奇, 何浩东, 蒋鸣, 等. 考虑倒塌因素的建筑物多弹累积毁伤效应分析 [J]. 防护工程, 2013, 35(4): 59–64.LI E Q, HE H D, JIANG M, et al. Numerical analysis of damage and collapse process of RC frame structures under repeated attacks [J]. Protective Engineering, 2013, 35(4): 59–64. [11] 章毅, 方秦, 陈力, 等. 多次爆炸荷载作用下梁的抗爆性能分析 [J]. 兵工学报, 2009, 30(S2): 182–187.ZHANG Y, FANG Q, CHEN L, et al. Blast resistant properties of reinforced concrete and steel beams subjected to multiple blast loads [J]. Acta Armamentarii, 2009, 30(S2): 182–187. [12] 杨大兴, 马林建, 马淑娜, 等. 常规武器对钢筋混凝土梁二次爆炸效应分析 [J]. 防护工程, 2012, 34(6): 38–41.YANG D X, MA L J, MA S N, et al. An analysis of the damage effects of a second conventional weapon explosion on reinforced concrete beams [J]. Protective Engineering, 2012, 34(6): 38–41. [13] 陈昊, 卢浩, 孙善政, 等. 常规武器二次爆炸作用下浅埋钢筋混凝土拱结构破坏规律 [J]. 爆炸与冲击, 2023, 43(8): 085104. DOI: 10.11883/bzycj-2022-0260.CHEN H, LU H, SUN S Z, et al. Failure law of shallow buried reinforced concrete arch structure under secondary explosion of conventional weapons [J]. Explosion and Shock Waves, 2023, 43(8): 085104. DOI: 10.11883/bzycj-2022-0260. [14] WILLIAMS G D, WILLIAMSON E B. Response of reinforced concrete bridge columns subjected to blast loads [J]. Journal of Structural Engineering, 2011, 137(9): 903–913. DOI: 10.1061/(ASCE)ST.1943-541X.0000440. [15] SHI Y C, HAO H, LI Z X. Numerical derivation of pressure–impulse diagrams for prediction of RC column damage to blast loads [J]. International Journal of Impact Engineering, 2008, 35(11): 1213–1227. DOI: 10.1016/j.ijimpeng.2007.09.001. [16] 王银, 孔祥振, 方秦, 等. 弹体对混凝土材料先侵彻后爆炸损伤破坏效应的数值模拟研究 [J]. 爆炸与冲击, 2022, 42(1): 013301. DOI: 10.11883/bzycj-2021-0132.WANG Y, KONG X Z, FANG Q, et al. Numerical investigation on damage and failure of concrete targets subjected to projectile penetration followed by explosion [J]. Explosion and Shock Waves, 2022, 42(1): 013301. DOI: 10.11883/bzycj-2021-0132. [17] WU Y C, CRAWFORD J E. Numerical modeling of concrete using a partially associative plasticity model [J]. Journal of Engineering Mechanics, 2015, 141(12): 04015051. DOI: 10.1061/(ASCE)EM.1943-7889.0000952. [18] 李猛深, 李杰, 李宏, 等. 爆炸荷载下钢筋混凝土梁的变形和破坏 [J]. 爆炸与冲击, 2015, 35(2): 177–183. DOI: 10.11883/1001-1455(2015)02-0177-07.LI M S, LI J, LI H, et al. Deformation and failure of reinforced concrete beams under blast loading [J]. Explosion and Shock Waves, 2015, 35(2): 177–183. DOI: 10.11883/1001-1455(2015)02-0177-07. [19] MOHAMMED T A. Reinforced concrete structural members under impact loading [D]. Toledo: University of Toledo, 2011. [20] KONG X Z, FANG Q, LI Q M, et al. Modified K&C model for cratering and scabbing of concrete slab under projectile impact [J]. International Journal of Impact Engineering, 2017, 108: 217–228. DOI: 10.1016/j.ijimpeng.2017.02.016. [21] 张学杰. 爆炸荷载作用下FRP加固钢筋混凝土柱动态响应精细化分析及损伤评估方法研究 [D]. 天津: 天津大学, 2020: 80–90.ZHANG X J. Research on methods for refined dynamic response analysis and damage assessment of FRP strengthened RC columns subjected to blast loading [D]. Tianjin: Tianjin University, 2020: 80–90. [22] Livermore Software Technology Corporation. Keyword user’s manua: l volume II: material models: LS-DYNA R11 [R]. California: Livermore Software Technology Corporation, 2010. [23] 陈旭光. 建筑物在侵爆作用下的累积毁伤评估 [D]. 长沙: 国防科技大学, 2019: 51–83.CHEN X G. Cumulative damage assessment of buildings under penetration and explosion [D]. Changsha: National University of Defense Technology, 2019: 51–83. [24] Federal Emergency Management Agency. Reference manual to mitigate potential terrorist attacks against buildings: FEMA-426 [R]. Washington: U. S. Department of Homeland Security, 2011. [25] Federal Emergency Management Agency. Risk assessment: FEMA-452 [R]. Washington: U. S. Department of Homeland Security, 2005. [26] KELLIHER D, SUTTON-SWABY K. Stochastic representation of blast load damage in a reinforced concrete building [J]. Structural Safety, 2012, 34(1): 407–417. DOI: 10.1016/j.strusafe.2011.08.001. [27] CAMPIDELLI M, TAIT M J, EL-DAKHAKHNI W W, et al. Numerical strategies for damage assessment of reinforced concrete block walls subjected to blast risk [J]. Engineering Structures, 2016, 127: 559–582. DOI: 10.1016/j.engstruct.2016.08.032. [28] ALMUSTAFA M K, NEHDI M L. Novel hybrid machine learning approach for predicting structural response of RC beams under blast loading [J]. Structures, 2022, 39: 1092–1106. DOI: 10.1016/j.istruc.2022.04.007. [29] US Army Corps of Engineers. Structures to resist the effects of accidental explosions: TM5-1300 [S]. Washington: Departments of the Army, the Navy, and the Air Force, 1990. [30] US Department of Defense. Structures to resist the effects of accidental explosions: UFC 3-340-02 [R]. Washington: The US Department of the Army, 2008. [31] 中国工程建设标准化协会. 民用建筑防爆设计标准: T/CECS 736-2020 [S]. 北京: 中国建筑工业出版社, 2020.China Association for Engineering Construction Standardization. Standard for blast protection design of civil buildings: T/CECS 736-2020 [S]. Beijing: China Architecture & Building Press, 2020. -
计量
- 文章访问数: 216
- HTML全文浏览量: 100
- PDF下载量: 126
- 被引次数: 0