Experimental study on dynamic response of high-density polyethylene bellows under blasting seismic load

ZHANG Yuqi; JIANG Nan; JIA Yongsheng; ZHOU Chuanbo; LUO Xuedong; WU Tingyao

doi:10.11883/bzycj-2019-0399

Volume 40 Issue 9

Sep. 2020

Turn off MathJax

Article Contents

Abstract

References

Article Navigation > Explosion And Shock Waves > 2020 > 40(9): 095901

ZHANG Yuqi, JIANG Nan, JIA Yongsheng, ZHOU Chuanbo, LUO Xuedong, WU Tingyao. Experimental study on dynamic response of high-density polyethylene bellows under blasting seismic load[J]. Explosion And Shock Waves, 2020, 40(9): 095901. doi: 10.11883/bzycj-2019-0399

Citation:

ZHANG Yuqi, JIANG Nan, JIA Yongsheng, ZHOU Chuanbo, LUO Xuedong, WU Tingyao. Experimental study on dynamic response of high-density polyethylene bellows under blasting seismic load[J]. Explosion And Shock Waves, 2020, 40(9): 095901. doi: 10.11883/bzycj-2019-0399

Citation:

ZHANG Yuqi, JIANG Nan, JIA Yongsheng, ZHOU Chuanbo, LUO Xuedong, WU Tingyao. Experimental study on dynamic response of high-density polyethylene bellows under blasting seismic load[J]. Explosion And Shock Waves, 2020, 40(9): 095901. doi: 10.11883/bzycj-2019-0399

PDF( 3577 KB)

Experimental study on dynamic response of high-density polyethylene bellows under blasting seismic load

doi: 10.11883/bzycj-2019-0399

ZHANG Yuqi^1
,,
JIANG Nan^{1, 2, 3
,
,},
JIA Yongsheng^{2, 3},
ZHOU Chuanbo¹,
LUO Xuedong¹,
WU Tingyao¹

1.
Faculty of Engineering, China University of Geosciences, Wuhan 430074, Hubei, China
2.
Hubei Key Laboratory of Engineering Blasting, Jianghan University, Wuhan, 430024, Hubei, China
3.
Wuhan Explosion & Blasting Co., Ltd, Wuhan, 430023, Hubei, China

Received Date: 2019-10-18
Rev Recd Date: 2020-05-24

Available Online: 2020-08-25

Publish Date: 2020-09-01

Abstract

Abstract

The dynamic response of buried high density polyethylene (HDPE) bellows under blasting seismic load was studied. First, the blasting test of buried pipeline was carried out by combining the blasting seismic test and dynamic strain test. Secondly, the dynamic response characteristics of buried pipeline under blasting seismic load were analyzed. Then, the characteristics of vibration velocity and dynamic strain distribution were studied. Finally, the pipe safety was evaluated based on the von Mises yield criterion, and the blasting vibration velocity control standard was proposed. The experimental results show that the vibration velocity of pipeline and ground and the dynamic strain of pipeline increase with the decrease of core distance and the increase of explosive quantity. The dominant frequency of blasting seismic wave is higher. The dominant frequency of pipeline is higher than the surface. Under the same blasting condition, the ground vibration velocity above the pipeline is generally higher than that of the pipeline. The peak axial strain on the back explosion side of the pipeline section is mainly tensile strain, and the peak circumferential strain on the front explosion side is mainly compressive strain. The vibration velocity of the pipeline can be safely controlled by 20 cm·s⁻¹, and the pipeline is in a safe state.
- blasting earthquake,
- HDPE bellows,
- field test,
- response characteristics,
- safety control

FullText(HTML)

References(24)

References

[1]	王栋, 何历超, 王凯. 钻爆法施工对邻近埋地管道影响的现场实测与数值模拟分析 [J]. 土木工程学报, 2017, 50(S2): 134–140. DOI: 10.15951/j.tmgcxb.2017.s2.021. WANG D, HE L C, WANG K. Field measurement and numerical simulation analysis for influence of blasting excavation on adjacent buried pipelines [J]. China Civil Engineering Journal, 2017, 50(S2): 134–140. DOI: 10.15951/j.tmgcxb.2017.s2.021.
[2]	GIANNAROS E, KOTZAKOLIOS T, KOSTOPOULOS V. Blast response of composite pipeline structure using finite element techniques [J]. Journal of Composite Materials, 2016, 50(25): 3459–3476. DOI: 10.1177/0021998315618768.
[3]	WON J H, KIM M K, KIM G, et al. Blast-induced dynamic response on the interface of a multilayered pipeline [J]. Structure and Infrastructure Engineering, 2014, 10(1): 80–92. DOI: 10.1080/15732479.2012.699532.
[4]	夏宇磬, 蒋楠, 姚颖康, 等. 粉质黏土层预埋承插式混凝土管道对爆破振动的动力响应 [J]. 爆炸与冲击, 2020, 40(4): 043302. DOI: 10.11883/bzycj-2019-0207. XIA Y Q, JIANG N, YAO Y K, et al. Dynamic responses of a concrete pipeline with bell-and-spigot joints buried in a silty clay layer to blasting seismic waves [J]. Explosion and Shock Waves, 2020, 40(4): 043302. DOI: 10.11883/bzycj-2019-0207.
[5]	HA D, ABDOUN T H, O’ROURKE M J, et al. Centrifuge modeling of earthquake effects on buried high-density polyethylene (HDPE) pipelines crossing fault zones [J]. Journal of Geotechnical and Geoenvironmental Engineering, 2008, 134(10): 1501–1515. DOI: 10.1061/(ASCE)1090-0241(2008)134:10(1501).
[6]	ABDOUN T H, HA D, O’ROURKE M J, et al. Factors influencing the behavior of buried pipelines subjected to earthquake faulting [J]. Soil Dynamics and Earthquake Engineering, 2009, 29(3): 415–427. DOI: 10.1016/j.soildyn.2008.04.006.
[7]	王海涛, 金慧, 贾金青, 等. 地铁隧道钻爆法施工对邻近埋地管道影响的模型试验研究 [J]. 岩石力学与工程学报, 2018, 37(S1): 3332–3339. DOI: 10.13722/j.cnki.jrme.2016.1409. WANG H T, JIN H, JIA J Q, et al. Model test study on the influence of subway tunnel drilling and blasting method on adjacent buried pipeline [J]. Chinese Journal of Rock Mechanics and Engineering, 2018, 37(S1): 3332–3339. DOI: 10.13722/j.cnki.jrme.2016.1409.
[8]	ZHANG J, ZHANG L, LIANG Z. Buckling failure of a buried pipeline subjected to ground explosions [J]. Process Safety and Environmental Protection, 2018, 114: 36–47. DOI: 10.1016/j.psep.2017.11.017.
[9]	PARVIZ M, AMINNEJAD B, FIOUZ A. Numerical simulation of dynamic response of water in buried pipeline under explosion [J]. KSCE Journal of Civil Engineering, 2017, 21(7): 2798–2806. DOI: 10.1007/s12205-017-0889-y.
[10]	娄敏, 明海芹. 基于LS-DYNA海底悬空管道受坠物碰撞动力响应分析 [J]. 海洋通报, 2015, 34(1): 113–120. DOI: 10.11840/j.issn.1001-6392.2015.01.017. LOU M, MING H Q. The dynamic response analysis of submarine suspended pipeline impacted by dropped objects based on LS-DYNA [J]. Marine Science Bulletin, 2015, 34(1): 113–120. DOI: 10.11840/j.issn.1001-6392.2015.01.017.
[11]	FRANCINI R B, BALTZ W N. Blasting and construction vibrations near existing pipelines: what are appropriate levels? [J]. Journal of Pipeline Engineering, 2009, 8(4): 519–531.
[12]	JIANG N, GAO T, ZHOU C B, et al. Effect of excavation blasting vibration on adjacent buried gas pipeline in a metro tunnel [J]. Tunnelling and Underground Space Technology, 2018, 81: 590–601. DOI: 10.1016/j.tust.2018.08.022.
[13]	张震, 周传波, 路世伟, 等. 爆破振动作用下邻近埋地混凝土管道动力响应特性 [J]. 哈尔滨工业大学学报, 2017, 46(9): 79–84. DOI: 10.11918/j.issn.0367-6234.201611089. ZHANG Z, ZHOU C B, LU S W, et al. Dynamic response characteristic of adjacent buried concrete pipeline subjected to blasting vibration [J]. Journal of Harbin Institute of Technology, 2017, 46(9): 79–84. DOI: 10.11918/j.issn.0367-6234.201611089.
[14]	朱斌, 蒋楠, 贾永胜, 等. 下穿燃气管道爆破振动效应现场试验研究 [J]. 岩石力学与工程学报, 2019, 38(12): 2582–2592. DOI: 10.13722/j.cnki.jrme.2019.0183. ZHU B, JIANG N, JIA Y S, et al. Field experiment on blasting vibration effect of underpass gas pipelines [J]. Chinese Journal of Rock Mechanics and Engineering, 2019, 38(12): 2582–2592. DOI: 10.13722/j.cnki.jrme.2019.0183.
[15]	贾永胜, 钟冬望, 姚颖康, 等. 基坑爆破预留层对围护桩的保护作用数值分析 [J]. 工程爆破, 2017, 23(5): 1–4, 21. DOI: 10.3969/j.issn.1006-7051.2017.05.001. JIA Y S, ZHONG D W, YAO Y K, et al. Numerical calculation of the barrier effect of the pre-protective layer on bored piles in deep foundation pit blasting [J]. Engineering Blasting, 2017, 23(5): 1–4, 21. DOI: 10.3969/j.issn.1006-7051.2017.05.001.
[16]	张震, 周传波, 路世伟, 等. 超浅埋地铁站通道爆破暗挖地表振动传播特征 [J]. 中南大学学报(自然科学版), 2017, 48(8): 2119–2125. DOI: 10.11817/j.issn.1672-7207.2017.08.020. ZHANG Z, ZHOU C B, LU S W, et al. Propagation characteristics of ground vibration induced by subsurface blasting excavation in an ultra-shallow buried underpass [J]. Journal of Central South University (Science and Technology), 2017, 48(8): 2119–2125. DOI: 10.11817/j.issn.1672-7207.2017.08.020.
[17]	肖文芳. 地铁隧道掘进爆破振动测试与数值模拟研究 [D]. 武汉: 武汉理工大学, 2011. XIAO W F. Study of vibration testing and numerical simulation on metro tunnel excavation blasting[D]. Wuhan: Wuhan University of Technology, 2011.
[18]	武卫星, 郭晓刚, 朱敏. 武汉轨道交通广虎区间隧道爆破施工方案优化 [J]. 人民长江, 2010, 41(10): 30–33. DOI: 10.16232/j.cnki.1001-4179.2010.10.009. WU W X, GUO X G, ZHU M. Optimization of blasting construction scheme of Guang-Hu section subway tunnels in Wuhan [J]. Yangtze River, 2010, 41(10): 30–33. DOI: 10.16232/j.cnki.1001-4179.2010.10.009.
[19]	钟冬望, 卢哲, 黄雄, 等. 爆破荷载下埋地PE管道动力响应的试验研究 [J]. 爆破, 2018, 35(4): 1–5; 89. DOI: 10.3963/j.issn.1001-487X.2018.04.001. ZHONG D W, LU Z, HUANG X. Experimental study on buried PE pipeline under blasting loads [J]. Blasting, 2018, 35(4): 1–5; 89. DOI: 10.3963/j.issn.1001-487X.2018.04.001.
[20]	钟冬望, 龚相超, 涂圣武, 等. 高饱和黏土中爆炸波作用下直埋聚乙烯管的动力响应 [J]. 爆炸与冲击, 2019, 39(3): 033102. DOI: 10.11883/bzycj-2017-0334. ZHONG D W, GONG X C, TU S W, et al. Dynamic responses of PE pipes directly buried in high saturated clay to blast wave [J]. Explosion and Shock Waves, 2019, 39(3): 033102. DOI: 10.11883/bzycj-2017-0334.
[21]	贵州省住房和城乡建设厅. DBJ52/T039-2017 室外埋地聚乙烯(PE)给水管道工程技术规程[S]. 2018.
[22]	罗利, 马燕, 张永军, 等. 地基沉降作用下埋地聚乙烯管强度失效的数值模拟 [J]. 建筑材料学报, 2020, 23(2): 473–478. LUO L, MA Y, ZHANG Y J, et al. Numerical simulation of strength failure of buried polyethylene pipes under foundation settlement [J]. Journal of Building Materials, 2020, 23(2): 473–478.
[23]	何平笙. 高聚物的力学性能[M]. 2版. 合肥: 中国科学技术大学出版社, 2008: 232−235.
[24]	舒亚俐. 既有给排水管线的震害及管道抗震能力关键问题综合分析 [J]. 城市道桥与防洪, 2013(3): 111–114. DOI: 10.16799/j.cnki.csdqyfh.2013.03.032. SHU Y L. Comprehensive analysis of seismic hazard to existing water and wastewater pipelines and key issues of seismic capacity of pipelines [J]. Urban Roads Bridges & Flood Control, 2013(3): 111–114. DOI: 10.16799/j.cnki.csdqyfh.2013.03.032.

Relative Articles

[1]	MENG Xianzhong, ZHOU Chuanbo, JIANG Nan, ZHANG Yuqi, ZHANG Zhen, WU Di. Generation mechanism and propagation characteristics of blasting seismic waves on tunnel surface[J]. Explosion And Shock Waves, 2024, 44(2): 025201. doi: 10.11883/bzycj-2023-0217
[2]	ZHANG Yuqi, JIANG Nan, ZHOU Chuanbo, YAO Yingkang, LI Haibo, CAI Zhongwei, HU Zongyao. Dynamic failure mechanism of HDPE pipelines with a gasketed bell and spigot joint subjected to blasting seismic load[J]. Explosion And Shock Waves, 2022, 42(12): 125101. doi: 10.11883/bzycj-2021-0492
[3]	GUO Xinxin, LIU Jinchao, WANG Bo, YU Wei, WANG Zhenyu, LI Haobin. Safety control standard of blasting vibration for tunnels with existing cracks and cavities[J]. Explosion And Shock Waves, 2020, 40(11): 115201. doi: 10.11883/bzycj-2019-0315
[4]	XIA Yuqing, JIANG Nan, YAO Yingkang, ZHOU Chuanbo, LUO Xuedong, WU Tingyao. Dynamic responses of a concrete pipeline with bell-and-spigot joints buried in a silty clay layer to blasting seismic waves[J]. Explosion And Shock Waves, 2020, 40(4): 043302. doi: 10.11883/bzycj-2019-0207
[5]	GAO Qidong, LU Wenbo, YANG Zhaowei, YAN Peng, CHEN Ming. Components and attenuation of seismic wavesinduced by horizontal smooth blasting[J]. Explosion And Shock Waves, 2019, 39(8): 085201. doi: 10.11883/bzycj-2018-0280
[6]	GONG Min, WU Haojun. High-speed photography image acquisition system in tunnel blasting and parameters study on precisely controlled blasting[J]. Explosion And Shock Waves, 2019, 39(5): 051101. doi: 10.11883/bzycj-2018-0319
[7]	Ye Haiwang, Tang Ke, Wan Tao, Wang Chao, Lei Tao, Li Xinping, C.M. Saliou. Optimization of time sequence controlled pre-splitting blasting parameters and its application[J]. Explosion And Shock Waves, 2017, 37(3): 502-509. doi: 10.11883/1001-1455(2017)03-0502-08
[8]	Lou Xiaoming, Zhou Wenhai, Jian Wenbing, Zheng Junjie. Control of delay time characterized by distribution of peak velocity-displacement vibration of millisecond blasting[J]. Explosion And Shock Waves, 2016, 36(6): 839-846. doi: 10.11883/1001-1455(2016)06-0839-08
[9]	Lu Liang, Long Yuan, Guo Tao, Xie Quan-min, Zhao Chang-xiao, Gao Fu-yin. Dynamic response sensitivity of urban tunnel structures under blasting seismic waves to parameters[J]. Explosion And Shock Waves, 2014, 34(6): 701-708. doi: 10.11883/1001-1455(2014)06-0701-08
[10]	WEI Hai-xia, CHEN Shi-ha. Effectsofthreemainfactorsofblastingseismicwaves onelastic-plasticseismicresponseofmultistorymasonrybuildings[J]. Explosion And Shock Waves, 2011, 31(1): 55-61. doi: 10.11883/1001-1455(2011)01-0055-07
[11]	CHEN Shi-hai, WEI Hai-xia, ZHANG An-kang, MAO Xiao-hui. Computationalmodelandsafetycriterionofblastingvibrationeffectbased onwaveletpackettechniques[J]. Explosion And Shock Waves, 2010, 30(4): 377-382. doi: 10.11883/1001-1455(2010)04-0377-06
[12]	LI Hong-tao, LU Wen-bo, SHU Da-qiang, YANG Xing-guo. An energy analysis method for blast-induced seismic based on power spectrum[J]. Explosion And Shock Waves, 2009, 29(5): 492-496. doi: 10.11883/1001-1455(2009)05-0492-05
[13]	LI Hong-tao, LU Wen-bo, SHU Da-qiang, YANG Xing-guo. Response spectrum of blasting vibration induced by tunnel excavation[J]. Explosion And Shock Waves, 2008, 28(4): 331-335. doi: 10.11883/1001-1455(2008)04-0331-05
[14]	SHEN Yong-kang, SHAO Jian-hua, CHEN Jian-feng. Precise integration analysis on blast seismic elasto-plastic responses of structures[J]. Explosion And Shock Waves, 2008, 28(1): 92-96. doi: 10.11883/1001-1455(2008)01-0092-05
[15]	ZHANG Dan, DUAN Heng-jian, ZENG Fu-hong. Experimental study on subordinate blasting seismic intensity[J]. Explosion And Shock Waves, 2006, 26(3): 279-283. doi: 10.11883/1001-1455(2006)03-0279-05
[16]	ZHONG Guo-sheng, XU Guo-yuan, XIONG Zheng-ming. Application research of the energy analysis method for blasting seismic signals based on wavelet transform[J]. Explosion And Shock Waves, 2006, 26(3): 222-227. doi: 10.11883/1001-1455(2006)03-0222-06

Supplements(0)

Cited By

Cited by

Periodical cited type(3)

1.	张玉琦，蒋楠，周传波，姚颖康，李海波，蔡忠伟，胡宗耀. 爆破地震荷载作用下承插式HDPE管道动力失效机制. 爆炸与冲击. 2022(12): 133-144 . 本站查看
2.	高文乐，李坤鹏，段耀奎，冯娜，张春玉. 埋地输油管道对爆破振动的动力响应. 爆破器材. 2021(01): 53-58 .
3.	夏宇磬，蒋楠，周传波，李海波，蒙贤忠. 爆破荷载作用大直径埋地管道振动响应解析. 振动.测试与诊断. 2022(01): 35-42+192-193 .