低温工况甲烷最小点火能实验研究

赵翔宇; 李洪波; 李自力; 崔淦; 付阳

doi:10.11883/bzycj-2016-0218

低温工况甲烷最小点火能实验研究

doi: 10.11883/bzycj-2016-0218

赵翔宇^{1, 2, 3},
李洪波^{1, 2, 3, ,},
李自力^{1, 2, 3},
崔淦^{1, 2, 3},
付阳⁴

1.
中国石油大学(华东)，山东青岛 266580
2.
山东省油气储运安全省级重点实验室，山东青岛 266580
3.
青岛市环海油气储运技术重点实验室，山东青岛 266580
4.
中国航空油料有限责任公司山东分公司，山东济南 250107

详细信息

作者简介:
赵翔宇(1991-)，男，硕士研究生

通讯作者:
李洪波，lihongbo@upc.edu.cn

中图分类号: O381
计量
- 文章访问数: 5406
- HTML全文浏览量: 1391
- PDF下载量: 212
- 被引次数: 0
出版历程
- 收稿日期: 2016-07-21
- 修回日期: 2016-08-31
- 刊出日期: 2018-03-25

Experimental study on the minimum ignition energy of methane at low temperature

ZHAO Xiangyu^{1, 2, 3},
LI Hongbo^{1, 2, 3
, ,},
LI Zili^{1, 2, 3},
CUI Gan^{1, 2, 3},
FU Yang⁴

1.
China University of Petroleum (East China), Qingdao 266580, Shandong, China
2.
Shandong Provincial Key Laboratory of Oil & Gas Storage and Transportation Safety, Qingdao 266580, Shandong, China
3.
Qingdao Key Laboratory of Circle Sea Oil & Gas Storage and Transportation Technology, Qingdao 266580, Shandong, China
4.
Shandong Branch, China National Aviation Fuel, Jinan 116023, Shandong, China

摘要

摘要: 为探索低温工况下甲烷的爆炸特性，利用自行构建的实验装置，测试了温度为-90~0 ℃、压力为0.1~0.5 MPa的条件下甲烷的最小点火能。研究表明：在研究范围内，随着压力的升高，甲烷的最小点火能减小，且低压时甲烷最小点火能随初始压力的增高减小较快，高压时减小较慢；随着温度的升高，甲烷最小点火能也减小，且低压时甲烷最小点火能随初始温度的增高减小较快，高压时减小较慢；甲烷的最小点火能分别与压力平方的倒数、温度的倒数呈近似线性关系。
- 甲烷 /
- 最小点火能 /
- 低温 /
- 压力
Abstract: In this paper, we tested the minimum ingition energy (MIE) of methane at low temperature using an experimental apparatus fabricated by ourselves to characterize the explosion of methane at a low temperature ranging from -90 to 0 ℃ and under a pressure ranging from 0.1 to 0.5 MPa. It was found that, within the scope of the study, as the pressure increases, the MIE of methane decreases and does so faster with the increase of the initial pressure under low pressure but more slowly under high pressure; as the temperature increases, the MIE of methane also decreases and does so faster with the increase of the initial temperature at low pressure but more slowly under high pressure; the MIE of methane is approximately linear with the reciprocal of the square of the pressure and the that of the temperature.
- methane /
- MIE /
- temperature /
- pressure

HTML全文

图 1 实验装置示意图

Figure 1. Schematic diagram of the experimental device

下载: 全尺寸图片幻灯片

图 2 点火电路

Figure 2. Ignition circuit

下载: 全尺寸图片幻灯片

图 3 点火时间-电流-电压曲线

Figure 3. Ignition time-current-voltage curve

下载: 全尺寸图片幻灯片

图 4 电极间隙对储存最小点火能的影响

Figure 4. Effect of electrode gap on storage MIE

下载: 全尺寸图片幻灯片

图 5 当量比对储存最小点火能的影响

Figure 5. Effect of equivalence ratio on storage MIE

下载: 全尺寸图片幻灯片

图 6 甲烷爆炸压力-时间采集曲线

Figure 6. Pressure-time acquisition curve of methane explosion

下载: 全尺寸图片幻灯片

图 7 计算结果与积分结果

Figure 7. Calculated value and the integral value

下载: 全尺寸图片幻灯片

图 8 压力对于最小点火能的影响

Figure 8. Effect of pressure on MIE

下载: 全尺寸图片幻灯片

图 9 压力与最小点火能的关系

Figure 9. Relationship between pressure and MIE

下载: 全尺寸图片幻灯片

图 10 温度对于最小点火能的影响

Figure 10. Effect of temperature on MIE

下载: 全尺寸图片幻灯片

图 11 温度与最小点火能的关系

Figure 11. Relationship between temperature and MIE

下载: 全尺寸图片幻灯片

表 1 本研究结果与其他研究结果对比

Table 1. Comparison of this research result with other research results

来源	E_m/mJ	不确定度	温度/K	压力/MPa	当量比
文献[4]	0.280	\	300	0.1	1
文献[14]	0.500	\	300	0.1	1
文献[13]	0.330	\	300	0.1	1
文献[15]	0.263	\	300	0.1	1
本文	0.49	±0.025	300	0.1	1

下载: 导出CSV

表 2 最小点火能测试结果及标准偏差

Table 2. MIE test results and standard deviation

压力/MPa	E_m/mJ				不确定度
压力/MPa	183 K	213 K	243 K	273 K	183 K	213 K	243 K	273 K
0.1	0.880	0.720	0.650	0.560	0.0160	0.0160	0.0220	0.0280
0.3	0.102	0.080	0.076	0.068	0.0070	0.0080	0.0110	0.0160
0.5	0.037	0.034	0.030	0.026	0.0014	0.0060	0.0100	0.0090

下载: 导出CSV

参考文献(15)

[1]	KARACAN C Ö, RUIZ F A, COTÈ M, et al. Coal Mine Methane: A review of capture and utilization practices with benefits to mining safety and to greenhouse gas reduction[J]. International Journal of Coal Geology, 2011, 86(2/3):121-156. https://www.cdc.gov/niosh/mining/UserFiles/works/pdfs/cmmar.pdf
[2]	钱伯章, 朱建芳.世界非常规天然气资源和利用进展[J].天然气与石油, 2007, 25(2):28-32. https://www.wenkuxiazai.com/doc/3be9c60eb7360b4c2e3f6428-3.html QIAN Bozhang, ZHU Jianfang. Non-regular natural gas resources in the world and utilization progress[J]. Natural Gas and Oil, 2007, 25(2):28-32. https://www.wenkuxiazai.com/doc/3be9c60eb7360b4c2e3f6428-3.html
[3]	VANDERSTRAETEN B, TUERLINCKX D, BERGHMANS J, et al. Experimental study of the pressure and temperature dependence on the upper flammability limit of methane/air mixtures[J]. Journal of Hazardous Materials, 1997, 56(3):237-246. doi: 10.1016/S0304-3894(97)00045-9
[4]	LEWIS B, VON ELBE G. Combustion, flames and explosions of gases[M]. New York: Academic Press, 1961.
[5]	ECKHOFF R K, NGO M, OLSEN W. On the minimum ignition energy (MIE) for propane/air[J]. Journal of Hazardous Materials, 2010, 175(1/2/3):293-297. https://www.sciencedirect.com/science/article/pii/S0304389409016409
[6]	SACKS H K, NOVAK T. A method for estimating the probability of lightning causing a methane ignition in an underground mine[C]//Las Meeting, 2006: 931-936.
[7]	HAN J, YAMASHITA H, HAYASHI N. Numerical study on the spark ignition characteristics of a methane-air mixture using detailed chemical kinetics effect of equivalence ratio, electrode gap distance, and electrode radius on MIE, quenching distance, and ignition delay[J]. Combustion & Flame, 2010, 157(7):1414-1421. https://www.researchgate.net/publication/255215763_Numerical_study_on_the_spark_ignition_characteristics_of_a_methane-air_mixture_using_detailed_chemical_kinetics_Effect_of_equivalence_ratio_electrode_gap_distance_and_electrode_radius_on_MIE_quenching
[8]	KELLEY A P, JOMAAS G, LAW C K. Critical radius for sustained propagation of spark-ignited spherical flame[J]. Combust & Flame, 2009, 156(5):1006-1013. https://www.sciencedirect.com/science/article/pii/S0010218008003933
[9]	谭迎新, 张景林, 张小春.可燃气体(或蒸气)爆炸参数测定[J].兵工学报, 1995, 16(2):56-60. https://www.wenkuxiazai.com/doc/9618e8f95acfa1c7aa00ccd8.html TAN Yingxin, ZHANG Jinglin, ZHANG Xiaochun. The determination of explosion characteristics of combustible gases(vapors)[J].Acta Armamentarii, 1995, 16(2):56-60. https://www.wenkuxiazai.com/doc/9618e8f95acfa1c7aa00ccd8.html
[10]	可燃气体与易燃液体蒸气最小静电点火能测定方法: GB/T 14288-93[S].
[11]	Determination of explosion limits of gases and vapours: BS-EN-1839_2003[S].
[12]	TANG C L, ZHANG S, SI Z B, et al. High methane natural gas/air explosion characteristics in confined vessel[J]. Journal of Hazardous Materials, 2014, 278:520-528. doi: 10.1016/j.jhazmat.2014.06.047
[13]	KONDO S, TAKAHASHI A, TOKUHASHI K. Calculation of minimum ignition energy of premixed gases[J]. Journal of Hazardous Materials, 2003, A103:11-23. https://www.sciencedirect.com/science/article/pii/S0304389403002267
[14]	YUASA T, KADOTA S, TSUE M, et al. Effects of energy deposition schedule on minimum ignition energy in spark ignition of methane/air mixtures[J]. Proceedings of the Combustion Institute, 2002, 29(1):743-750. doi: 10.1016/S1540-7489(02)80095-5
[15]	WANG B, LIU X, XIE C. Effect of temperature on the minimum ignition energy (MIE) of the hydrocarbon combustible gas[J]. Journal of Safety and Environment, 2016, 16(2):92. http://www.en.cnki.com.cn/Article_en/CJFDTotal-AQHJ201602020.htm