基于多普勒测速技术的JB-9014炸药反应区结构研究

裴红波; 黄文斌; 覃锦程; 张旭; 赵锋; 郑贤旭

doi:10.11883/bzycj-2017-0379

基于多普勒测速技术的JB-9014炸药反应区结构研究

doi: 10.11883/bzycj-2017-0379

中国工程物理研究院流体物理研究所, 四川绵阳 621999

基金项目:

国家自然科学基金项目 11602248

科学挑战专题项目 TZ2018001

国防科工局技术基础项目 JSZL2015212C001

详细信息

作者简介:
裴红波(1987-), 男, 博士, 助理研究员

通讯作者:
黄文斌, caephwb@163.com

中图分类号: O381
计量
- 文章访问数: 5360
- HTML全文浏览量: 1480
- PDF下载量: 238
- 被引次数: 0
出版历程
- 收稿日期: 2017-10-18
- 修回日期: 2017-11-15
- 刊出日期: 2018-05-25

Reaction zone structure of JB-9014 explosive measured by PDV

Institute of Fluid Physics, China Academy of Engineering Physics, Mianyang 621999, Sichuan, China

摘要

摘要: 为了解TATB基JB-9014炸药的爆轰过程，利用火炮驱动飞片加载，采用光子多普勒测速技术，对JB-9014炸药的爆轰反应区结构进行了实验研究。实验中利用火炮发射高速蓝宝石飞片冲击起爆被测炸药，在炸药后表面安装镀膜氟化锂（LiF）窗口测量炸药爆轰时的界面粒子速度，测试过程的时间分辨率小于2 ns。将粒子速度剖面对时间进行一阶求导，通过一阶导数的拐点来确定炸药反应区宽度、反应时间。研究结果表明，钝感炸药JB-9014的反应时间为（0.26±0.02）μs，对应的化学反应区宽度为（1.5±0.2）mm，反应结束点处的压力为27.3 GPa，von Neumann峰处压力为40.3 GPa。
- 光子多普勒测速仪 /
- JB-9014炸药 /
- 氟化锂窗口 /
- 粒子速度 /
- 反应区结构
Abstract: To understand the detonation reaction process of the TATB-based JB-9014 explosive, experimental measurements of the detonation wave profile of solid explosives using photon Doppler velocimetry (PDV) were performed. Planar detonations were produced by impacting the explosive with a sapphire flyer in a gas gun. Particle velocity wave profiles were measured at the explosive/window interface using PDV. LiF windows with very thin vapor deposited aluminum mirrors were used, and the time resolution of the measuring system was less than 2 ns. The interface velocity histories were derived to determine the reaction zone length and reaction time. The results show that the reaction time of JB-9014 is (0.26±0.02) μs, and the corresponding reaction zone length is (1.5±0.2) mm. The pressure at the end of chemical reaction is 27.3 GPa, the pressure at von Neumann spike is 40.3 GPa.
- photon Doppler velocimetry /
- JB-9014 explosive /
- LiF windows /
- particle velocity /
- reaction zone structure

HTML全文

图 1 爆轰反应区结构示意图

Figure 1. Schematic of the detonation wave profile

下载: 全尺寸图片幻灯片

图 2 测试系统示意图

Figure 2. Schematic of measurement system

下载: 全尺寸图片幻灯片

图 3 实验界面粒子速度历程

Figure 3. Experimental interface particle velocity-time curves

下载: 全尺寸图片幻灯片

图 4 界面粒子加速度

Figure 4. Interface particle acceleration history

下载: 全尺寸图片幻灯片

表 1 TATB基炸药反应区时间和宽度

Table 1. Time and length of reaction zone for TATB-based explosive

炸药	方法	τ/μs	a/mm	来源	备注
JB-9014	激光测速+粒子速度求导	0.26±0.02	1.5±0.2	本文
PBX9502	激光测速+炸药状态方程	0.28	2.1	Sheffield等^[7]
PBX9502	曲率效应试验+数值模拟		2.9	Wescott等^[19]
PBX9502	激光测速+数值模拟	0.3	2	Seitz等^[8]
PBX9502	激光测速+炸药状态方程	0.21±0.02 0.28±0.01		Dattelbaum等^[20]	LiF窗口 Kel-F窗口
JB-9014	光电法+粒子速度求导	0.31	1.75	赵同虎等^[5]
TATB/inert	光电法+粒子速度求导	0.26±0.05	1.24±0.17	Loboiko等^[6]

下载: 导出CSV

参考文献(21)

[1]	DUFF R E, HOUSTON E. Measurement of the Chapman Jouguet pressure and reaction zone length in a detonating high explosive[J]. Journal of Chemical Physics, 1955, 23(7):1268-1273. DOI: 10.1063/1.1742255.
[2]	张宝坪, 张庆明, 黄风雷.爆轰物理学[M].北京:兵器工业出版社, 2001:151-153.
[3]	TASKER D G, LEE R J. The measurement of electrical conductivity in the detonating condensed explosives[C]//Proceedings of the 9th International Detonation Symposium. USA: Office of Naval Research, 1989: 123-126.
[4]	LEE R J, GUSTAVSON P K. Electrical conductivity as a realtime probe of secondary combustion of solid-fuel additives in detonating explosives[C]//Shock Compression of Condensed Matter 2003. USA: American Institute of Physics, 2004: 1273-1276.
[5]	赵同虎, 张新彦, 李斌, 等.用光电法研究钝感炸药JB-9014反应区结构[J].高压物理学报, 2002, 16(2):111-119. DOI: 10.11858/gywlxb.2002.02.005. ZHAO Tonghu, ZHANG Xinyan, LI Bin, et al. Detonation reaction zone structure of JB-9014[J]. Chinese Journal of High Pressure Physics, 2002, 16(2):111-119. DOI: 10.11858/gywlxb.2002.02.005.
[6]	LOBOIKO B L, LUBYATINSKY S N. Reaction zones of detonating solid explosives[J]. Combustion, Explosion, and Shock Waves, 2000, 36(6):716-733. DOI: 10.1023/A:1002898505288.
[7]	SHEFFIELD S A, BLOOMQUIST D D, TARVER C M. Subnanosecond measurements of detonation fronts in solid high explosives[J]. Journal of Chemical Physics, 1984, 80(8):3831-3844. DOI: 10.1063/1.447164.
[8]	SEITZ W L, STACY H L, ENGELKE R, et al. Detonation reaction-zone structure of PBX-9502[C]//Proceedings of the 9th International Detonation Symposium. USA: Office of Naval Research, 1989: 675-682.
[9]	GUSTAVSEN R L, BARTRAM B D, SANCHEZ N. Detonation wave profiles measured in plastic bonded explosives using 1550 nm photon Doppler velocimetry (PDV)[C]//Shock Compression of Condensed Matter 2009. USA: American Institute of Physics, 2009: 253-256.
[10]	BOUYER V, DOUCET M, DECARIS L. Experimental measurements of the detonation wave profile in a TATB based explosive[C]//EPJ Web of Conference. France: EDP Science, 2010: 378-384.
[11]	BOUYER V, HEBERT P, DOUCET M, et al. Experimental measurements of the chemical reaction zone of TATB and HMX based explosives[C]//Shock Compression of Condensed Matter 2011. USA: American Institute of Physics, 2012: 209-212.
[12]	BOUYER V, SHEFFIELD S A, DATTELBAUM D M, et al. Experimental measurements of the chemical reaction zone of detonating liquid explosives[C]//Shock Compression of Condensed Matter 2009. USA: American Institute of Physics, 2009: 177-180.
[13]	STRAND O T, GOOSMAN D R, MARTINEZ C, et al. Compact system for high-speed velocimetry using heterodyne techniques[J]. Review of Scientific Instruments, 2006, 77(8):083108. doi: 10.1063/1.2336749
[14]	项红亮, 王建, 毕重连, 等.光子多普勒速度测量系统的数据处理方法[J].光学与光电技术, 2012, 10(2):52-56. http://www.wanfangdata.com.cn/details/detail.do?_type=degree&id=Y2221259 XIANG Hongliang, WANG Jian, BI Chonglian, et al. Data processing of photonic Doppler velocimetry system[J]. Optics & Optoelectronic Technology, 2012, 10(2):52-56. http://www.wanfangdata.com.cn/details/detail.do?_type=degree&id=Y2221259
[15]	LIU S, WANG D, LI T, et al. Analysis of photonic Doppler velocimetry data based on the continuous wavelet transform[J]. Review of Scientific Instruments, 2011, 82(2):593-599. DOI: 10.1063/1.3534011.
[16]	赵万广, 周显明, 李加波, 等.LiF单晶的高压折射率及窗口速度的修正[J].高压物理学报, 2014, 28(5):571-576. DOI: 10.11858/gywlxb.2014.05.010. ZHAO Wanguang, ZHOU Xianming, LI Jiabo, et al. Refractive index of LiF single crystal at high pressure and its window correction[J]. Chinese Journal of High Pressure Physics, 2014, 28(5):571-576. DOI: 10.11858/gywlxb.2014.05.010.
[17]	JENSEN B J, HOLTKAMP D B, RIGG P A, et al. Accuracy limits and window corrections for photon Doppler velocimetry[J]. Journal of Applied Physics, 2007, 101(1):523-454. DOI: 10.1063/1.2407290.
[18]	TARVER C M. Detonation reaction zones in condensed explosives[C]//Shock Compression of Condensed Matter 2005. USA: American Institute of Physics, 2005: 1026-1029.
[19]	WESCOTT B L, STEWART D S, DAVIS W C. Equation of state and reaction rate for condensed-phase explosives[J]. Journal of Applied Physics, 2005, 98(5):90-98.
[20]	DATTELBAUM D M, GUSTAVSEN R L, ASLAM T, et al. Influence of window characteristics on chemical reaction zone measurements in PBX 9502[C]//Proceedings of the 15th International Detonation Symposium. USA: Office of Naval Research, 2014: 396-406. DOI: 10.1063/1.2035310.
[21]	MADER C L. Numerical modeling of detonation[M]. Berkely, California:University of California Press, 1979:69-70.